How to remove door panel?

How to remove door panel?

Postby red98tj [OP] » January 18th 2010, 4:50pm

Hi. I need to replace the drivers side power window motor on my 2000. Is the interior panel held in place by plastic clips around the perimeter only, or are there other fasteners to remove? I just dont want to break anything trying to get it off. thanks :banana:
Vehicles:
2005 Chevy Avalanchesold
2000 Chevy Astro AWDsold
2003 Chrysler T&C AWD
2003 GMC Yukon XL 2500 Quadrasteer
2007 Chrysler Pacifica awd
2012 Keystone Outback 312bh
Original Poster [OP]
red98tj
Fueling (1/2 tank)
Fueling (1/2 tank)
Years of Membership: red98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full years
Posts: 51
Topics: 10
Joined: February 2009
Location: Maine
Gender: Male
Alias (AKA): kevin
Van Make/Model: Chevrolet Astro
Extra Info: LT AWD

  • Similar topics
    Replies
    Views
    Author
  • Power Door Panel Replacement Question
    by oktrailstomper » September 26th 2016, 6:54pm in Interior
    2 Replies
    175 Views
    Last post by oktrailstomper View the latest post
    September 29th 2016, 6:19pm
  • Pull handle for passenger door panel
    by cathairez » December 7th 2016, 6:04pm in Interior
    6 Replies
    201 Views
    Last post by cathairez View the latest post
    December 12th 2016, 7:07pm
  •  
    7
    35
    Last post by AstroSafari.com View the latest post
    February 26th 2017, 1:54am

Re: How to remove door panel?

Postby red98tj [OP] » January 18th 2010, 7:50pm

nevermind, I found a good writeup about this here,
http://www.ehow.com/how_5259811_remove-chevy-astro-door-panel.html

It looks like the armrest portion comes out separately. That is good as I can bring it inside and install the new plastic cap I bought for it (The vinyl is cracked). It is too cold out now for the silicone to cure properly.
Vehicles:
2005 Chevy Avalanchesold
2000 Chevy Astro AWDsold
2003 Chrysler T&C AWD
2003 GMC Yukon XL 2500 Quadrasteer
2007 Chrysler Pacifica awd
2012 Keystone Outback 312bh
Original Poster [OP]
red98tj
Fueling (1/2 tank)
Fueling (1/2 tank)
Years of Membership: red98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full years
Posts: 51
Topics: 10
Joined: February 2009
Location: Maine
Gender: Male
Alias (AKA): kevin
Van Make/Model: Chevrolet Astro
Extra Info: LT AWD

Re: How to remove door panel?

Postby diego89 » January 19th 2010, 7:31am

also the thing at the top of the door panel needs to come off first before the panel. it has one pin on the back, then you need to lift up. i used a picture from Jasen. Its the part where the tweeter is.

.Image
User avatar
diego89
250k+ Miles
250k+ Miles
Firing on 4 Cylinders (L1)
Firing on 4 Cylinders (L1)
Years of Membership: diego89 has been a member for 7 full yearsdiego89 has been a member for 7 full yearsdiego89 has been a member for 7 full yearsdiego89 has been a member for 7 full yearsdiego89 has been a member for 7 full yearsdiego89 has been a member for 7 full yearsdiego89 has been a member for 7 full years
Posts: 419
Topics: 40
Images: 4
Joined: September 2009
Location: Oxnard, CA
Gender: Male
Van Make/Model: Chevrolet Astro
Extra Info: with opt. hydraulics

Re: How to remove door panel?

Postby red98tj [OP] » January 20th 2010, 1:24am

Yes, thanks. I finished up the job today. I could not find any metal screws the right size to fill in the drilled out rivets, so I just clocked the motor slightly and installed 4 self tap sheet metal scews.
Vehicles:
2005 Chevy Avalanchesold
2000 Chevy Astro AWDsold
2003 Chrysler T&C AWD
2003 GMC Yukon XL 2500 Quadrasteer
2007 Chrysler Pacifica awd
2012 Keystone Outback 312bh
Original Poster [OP]
red98tj
Fueling (1/2 tank)
Fueling (1/2 tank)
Years of Membership: red98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full yearsred98tj has been a member for 8 full years
Posts: 51
Topics: 10
Joined: February 2009
Location: Maine
Gender: Male
Alias (AKA): kevin
Van Make/Model: Chevrolet Astro
Extra Info: LT AWD


 
  • Related topics
    Replies
    Views
    Last post

Return to Interior

It is currently February 26th 2017, 1:54am

Interior Forum
InteriorDiscuss the cabin from the headliner to the carpeting of your Astro or Safari van. Topics include door panels, and seat belts or the dash and carpet, trim, and seats. Talk about your center console, seats, door handles, upholstery, steering wheels or any other item in the cab of your van.
To create a new topic in Interior, click this button:
Previous topic Next topic
Recent Image Attachments
Attached by:
Attached by: nosxjeep
nosxjeep
in Interior
Views: 198
Comments: 16
Date: Feb 23 '17
Time: 10:24pm
» Read last comment
Attached by:
Attached by: nosxjeep
nosxjeep
in Interior
Views: 198
Comments: 16
Date: Feb 23 '17
Time: 8:30pm
» Read last comment
Attached by:
Attached by: chopsaw209
chopsaw209
in Interior
Views: 76686
Comments: 237
Date: Feb 17 '17
Time: 5:20pm
» Read last comment
Attached by:
Attached by: chopsaw209
chopsaw209
in Interior
Views: 76686
Comments: 237
Date: Feb 14 '17
Time: 5:48am
» Read last comment
Attached by:
Attached by: chopsaw209
chopsaw209
in Interior
Views: 76686
Comments: 237
Date: Feb 12 '17
Time: 4:55am
» Read last comment
Sponsors
 

Who is online

Users browsing this forum: No registered users and 3 guests